The Last Grain Race

I asked him whether he had just joined the ship, but he replied that this would be his second voyage. Moshulu had been on the timber run from Finland to Lourenço Marques in Portuguese East Africa in 1937 before going to Australia for her grain cargo. I was glad; at least he was not leaving, as many of the others were. I had already begun to cling to any acquaintance as a drowning man clutches a straw.

It so happened that I met not the First Mate but the Second, as everything was in a state of flux: some members of the crew were signing off and returning to Mariehamn, others arriving to take their place. The old Captain, Boman, who had commanded her since she joined the Erikson fleet, was going home and being replaced by Captain Sjögren who was coming from the Archibald Russell.

The Second Mate was thin, watery-eyed and bad-tempered. At sea he was to prove much better than he looked to me this morning. He did not like ports and he did not like to see the ship in her present state. My arrival did not seem propitious and after dressing me down for not reporting aft directly I had come on board, he suddenly shot at me: ‘Ever been aloft before?’

‘No, sir.’

We were standing amidships by the mainmast. He pointed to the lower main shrouds which supported the mast and said simply: ‘Op you go then.’ I could scarcely believe my ears, I had imagined that I should be allowed at least a day or two to become used to the ship and the feel of things, but this was my introduction to discipline. I looked at the Mate. He had a nasty glint in his eye and I decided I was more afraid of him than of the rigging. If I was killed it would be his fault, not mine, I said to myself with little satisfaction. Nevertheless I asked him if I could change my shoes which had slippery soles.

High rigging

‘Change your shoes? Op the rigging.’ He was becoming impatient.

At this time Moshulu was the greatest sailing ship in commission, and probably the tallest. Her main mast cap was 198 feet above the keel. I started towards the main rigging on the starboard side nearest the quay but was brought back by a cry from the Mate.

‘Babord, port side. If you fall you may fall in the dock. When we’re at sea you will always use the weather rigging, that’s the side from which the wind blows. Never the lee rigging. And when I give you an order you repeat it.’

‘Op the rigging,’ I said.

The first part of the climb seemed easy enough. The lower main shrouds supporting the mast were of heavy wire made from plough steel and the first five ratlines were iron bars seized across four shrouds to make a kind of ladder which several men could climb at once. Above them the ratlines were wooden bars seized to the two centre shrouds only, the space for the feet becoming narrower as they converged at the ‘top’, eighty feet up, where it was difficult to insert a foot as large as mine in the ratlines at all. Before reaching this point, however, I came abreast of the main yard. It was of tapered steel, ninety-five and a half feet from arm to arm, two and a half feet in diameter at the centre and weighed over five tons. It was trussed to the mainmast by an iron axle and preventer chain which allowed it to be swung horizontally from side to side by means of tackle to the yardarms; an operation known as ‘bracing’.

Above me was the ‘top’, a roughly semi-circular platform with gratings in it. This was braced to the mast by steel struts called futtock shrouds. To get to the ‘top’ I had to climb outwards on the rope ratlines seized to the futtock shrouds. There was a hole in the ‘top’ which it was considered unsporting to use. I only did so once for the experience and cut my ear badly on a sharp projection which was probably put there as a deterrent. I found difficulty in reaching the top this first time and remained transfixed, my back nearly parallel with the deck below, whilst I felt for a rope ratline with one foot. I found it at last and heaved myself, nearly sick with apprehension, on to the platform, where I stood for a moment, my heart thumping. There was only a moment’s respite, in which I noticed that the mainmast and the topmast were in one piece – not doubled as in most sailing ships – before the dreadful voice of the Mate came rasping up at me:

‘Get on op.’

The next part was nearly fifty feet of rope ratlines seized to the topmast shrouds. Almost vertical, they swayed violently as I went aloft; many of them were rotten and one broke underfoot when I was at the level of the topsail yards. Again the voice from the deck:

‘If you want to live, hold on to those shrouds and leave the bloody ratlines alone.’

The lower topsail yard was slung from an iron crane but the upper topsail yard above it was attached to a track on the foreside of the topmast allowing the yard to be raided by means of a halliard more than twenty-five feet almost to the level of the crosstrees. The crosstrees formed an open frame of steel girdering about 130 feet up, at the heel of the topgallant mast. Originally the topsail had been a single sail, but to make it easier for the reduced crews to take in sail, it had been divided into two. At the moment the upper topsail yard was in its lowered position, immediately on top of the lower topsail yard. The crosstrees seemed flimsy when I reached them; two long arms extended aft from the triangle, spreading the backstays of the royal mast, the highest mast of all. I stood gingerly on this slippery construction; the soles of my shoes were like glass; all Belfast spread out below. I looked between my legs down to a deck as thin as a ruler and nearly fell from sheer funk.

‘Op to the royal yard,’ came the imperious voice, fainter now. Another forty feet or so of trembling topgallant shroud, past the lower and upper topgallant yards, the upper one, like the upper topsail yard, movable on its greased track. The ratlines were very narrow now and ceased altogether just below the level of the royal yard.

I was pretty well all in emotionally and physically but the by now expected cry of ‘Out on the yard’ helped me to heave myself on to it. In doing so I covered myself with grease from the mast track on which the royal yard moved up and down. It was fifty feet long and thinner than those below it. As on all the other yards, an iron rail ran along the top. This was the jackstay, to which the sail was bent. (In cadet training ships this rail would have had another parallel to hold on to, as, with the sail bent to the forward jackstay, there was little or no handhold. Moshulu had not been built for cadets and this refinement was lacking. With no sails bent what I had to do was easy, but I did not appreciate my good fortune at the time.) Underneath the yard was a wire rope which extended the length of it and was supported half-way between the mast and either yard-arm by vertical stirrups. This footrope was called the ‘horse’ and when I ventured out on it I found it slippery as well as slack so that both feet skidded in opposite directions, leaving me like a dancer about to do the splits, hanging on grimly to the jackstay.

‘Out. Right out to the yardarm,’ came the Mate’s voice, fainted still. I hated him at this moment. There were none of the ‘joosts’ and ‘ploddys’ of the stylised Scandinavian to make me feel superior to this grim officer. He spoke excellent English.

Somehow I reached the yardarm. I tried to rest my stomach on it, and stick my legs out behind me but I was too tall; the foot-rope came very close up to the yard at this point, where it was shackled to the brace pendant, and my knees reached to the place on the yard where the riggers had intended my stomach to be, so that I had the sensation of pitching headlong over it. Fortunately there was a lift shackled to the yardarm band, a wire tackle which supported the yard in its lowered position, and to this I clung whilst I looked about me.

What I saw was very impressive and disagreeable. By now I had forgotten what the Mate had said about falling into the dock and I was right out at the starboard yardarm, 160 feet above the sheds into which Moshulu’s 62,000 sacks of grain were being unloaded. The rooftops of these sheds were glass and I remember wondering what would happen if I fell. Would I avoid being cut to pieces by the maze of wires below, or miss them and make either a large expensive crater in the roof or a smaller one shaped like me? I also wondered what kind of technique the ambulance men employed to scoop up what was left of people who fell from such heights. I tried to dismiss these melancholy thoughts but the beetle-like figures on the dock below that were stevedores only accentuated my remoteness. The distant prospect was more supportable: a tremendous panorama beyond the city to the Antrim Hills and far up the Lough to the sea.

‘Orlright,’ called the Mate. ‘Come in to the mast.’ I did so with alacrity, but was not pleased when he told me to go to the truck on the very top of the mast. I knew that with these blasted shoes I could never climb the bare pole, so I took them off, and my socks too, and wedged them under the jackstay.

There were two or three very rotten ratlines seized across the royal backstays. The lowest broke under my weight so I used the backstays alone to climb up to the level of the royal halliard sheave to which the yard was raised when sail was set. Above this was nothing. Only six feet of bare pole to the truck. I was past caring whether I fell or not.

I embraced the royal mast and shinned up. The wind blew my hair over my nose and made me want to sneeze. I stretched out my arm and grasped the round hardwood cap 198 feet above the keel and was surprised to find it was not loose or full of chocolate creams as a prize. Now the bloody man below me was telling me to sit on it, but I ignored him. I could think of no emergency that would make it necessary. So I slid down to the royal halliard and to the yard again.

‘You can come down now,’ shouted the Mate. I did. It was worse than going up and more agonising as I was barefoot, with my shoes stuffed inside my shirt.

‘You were a fool to take your shoes off,’ said the Mate when I reached the deck. ‘Now you can learn to clean the lavatories.’

Since that day I have been aloft in high rigging many hundreds of times and in every kind of weather but I still get that cold feeling in the pit of the stomach when I think of the first morning out on the royal yard with the sheds of the York Dock below.

TECHNICAL INTERLUDE

(Surface at ‘That night I went ashorev…’)

In the afternoon I went with a number of other newly arrived crew to sign some papers at the office of the Finnish Consul. Afterwards Vytautas took me over the ship. The strength and size of her steel top hamper was matched by that of her immense steel hull – into which more than 4,800 tons of grain would be packed. Moshulu’s gross tonnage (that is to say, the entire internal volume expressed in units of 100 cubic feet to a ton) was 3,116. She drew twenty-six feet of water when loaded and measured 335 feet on the waterline.

She had a very handsome, fine bow entrance somehow disproportionate to her rather heavy overall appearance; a tiny poop only twenty feet long also contrived to spoil her looks when seen from the beam, but the general effect was undeniably impressive. Like Archibald Russell, Moshulu was fitted with bilge keels to make her more stable. Above the loadline the hull was painted black except for the upper works of the amidships, which were white. Her masts and spars were light yellow. Under the bowsprit there was no splendid figurehead like those of the Killoran and Pommern, only on the beak beneath the bowsprit a carved boss with a coat-of-arms picked out in yellow and blue, the house mark of Siemers, the Hamburg owners who had had her originally in the nitrate trade.

The masts, fore, main, mizzen and jigger, were each supported by a system of heavy fore-and-aft stays, six on the foremast, four on the main and mizzen, three on the jigger. On the foremast the forestay that supported it was a double stay set up taut with rigging screws shackled into the deck on the fo’c’sle head. The fore topmast stay, the next above the forestay, was also a double stay led through blocks on either side of the bowsprit and passed round rigging screws. The bowsprit itself was held rigid by two stays underneath it, the outer and inner bobstays, and on each side by three bowsprit guys shackled into the bows.

The three square-rigged masts were supported by shrouds of heavy wire; three pairs of lower shrouds extending from the bulwarks to the ‘top,’ round the mast and back to the bulwarks; three topmast shrouds extending from the ‘top’ to the crosstrees; and two topgallant shrouds above. From aft came great stresses and there were nine backstays on each mast to meet them. Both lower shrouds and backstays were set up to the hull plating and tautened by heavy rigging screws. All the doublings were wormed, parcelled, served and painted black; the seizings were white, one of the few concessions to the picturesque in the whole ship.

In the days when a ship’s masts and yards were wooden, the rigging was of hemp, set up with lanyards and deadeyes. In a dismasting it was sometimes possible to cut away the wreckage and allow it to go by the board; but the shrouds and backstays of Moshulu’s standing rigging were of steel wire so thick and strong that if the masts went over the side and one set of rigging screws was torn bodily out of the ship, it would be a tremendous job to cut away the slack rigging on the lee side without special equipment if the rigging screws stripped their threads.

Each square-rigged mast crossed six yards to which six sails were bent, a total of eighteen: the royal, upper and lower topgallants, upper and lower topsails and below these the big course-sails, fore, main and mizzen. There was a total of thirteen fore-and-aft sails: four head sails set on the forestays to the bowsprit – the flying jib outermost, set on the fore topgallant stay, the outer and inner jibs and the fore topmast staysail all set on their respective stays. In addition there were two staysails set on the topmast and topgallant forestays between each mast, six in all. There could have been royal staysails too, but they were never set in Moshulu while I was in her. With a small crew topgallant staysails were more than enough. Once we set a fore royal staysail beyond the flying jib, but it blew out in a squall and the experiment was not repeated. All the fore-and-aft sails had downhauls for taking them in and halliards for setting them. On the jigger mast there were three fore-and-aft sails, a triangular gaff topsail, an upper spanker between the upper gaff and the gaff boom and biggest of all, the lower spanker. The two lower sails were controlled by brails and were difficult to furl. The arrangement of three sails on the after mast was peculiar to the ex-German nitrate traders. Most barques only had two. With all these sails set, Moshulu’s sail area was in the region of 45,000 square feet.

Vytautas took me right out on the bowsprit. Into the tip of it several nails had been driven, to which some dried horny fragments adhered.

‘Shark’s fins,’ said Vytautas. ‘Good luck, not much of it left now.’ We were facing one another on the footrope. ‘Very dangerous here,’ he said happily. ‘No netting under the bowsprit. If she runs heavily she may dip and wash you off. If you are sent to furl the “Jagare”, that’s the flying jib, look out for the sheet block, it can easily knock you into the water. Remember, please,’ he added a little more wistfully, ‘if you fall from here the ship will go over you and by the time she can heave-to it will be too late to find you.’

I was suitably impressed by these observations and had reason to remember them on many occasions during the voyage.

We worked our way down the bowsprit to the white-railed fo’c’sle head deck, the raised part of the ship at the bows. To port and starboard were Moshulu’s bower anchors, of the old-fashioned kind with stocks, lashed down to the deck. Their stocks prevented them being hauled close up to the hawse pipes, and there was a small crane to lift them on board. Beneath the crane was a teak pin rail with iron pins in it to which the downhauls of the headsails were belayed. The sheets led to pin rails on either side of the fo’c’sle head just above the well deck. In addition there was a capstan with square holes in it to take the heads of the wooden capstan bars. At sea this capstan was used for hauling down the tack of the foresail when the vessel was beating into the wind, but it could also be geared to the anchor windlass beneath the fo’c’sle head. On both sides of the capstan there were massive bitts to which the tack of the foresail could be made fast.

At the break of the raised deck were the two lighthouses which protected the port and starboard navigation lights; each could be entered through a hole in the roof of the lamp rooms under the fo’c’sle head. In port, the copper domes of these lighthouses were neglected and bright green from exposure, but at sea, unless the weather was very bad, they were kept brightly burnished. Two companion ladders led to the well-deck below, and between them hung in a sort of gallows the big bronze bell with Kurt, Hamburg (the name given her by her German owners), engraved on it.

Lashed up next to the bell, with its heel on the deck, was the spare sheet-anchor. Immediately below the lighthouses on the well-deck were the pigsties, built solidly of steel but for the present untenanted.

Underneath the fo’c’sle head-deck were the lavatories, ablution rooms, blacksmith’s stores, the boatswain’s store, and the port and starboard lamp-rooms. It was a draughty, smelly part of the ship. The lavatories were very gruesome, with no locks on the doors and no flushing arrangements. I had spent a memorable half-hour on the first morning cleaning them with a long iron rod and innumerable buckets of dirty dock-water. This was the most disgusting task I have ever been called upon to perform in peace or war. In war not even the pits beside the railway tracks so thoughtfully provided by the Germans for our convenience when we were being moved westwards in chains from Czechoslovakia equalled the lavatories in Moshulu.

Between the two washrooms stood the anchor windlass with its massive cables, and the salt-water pump, a very rickety affair with a pipeline aft to the main deck.

Immediately aft of the pump was No 1 hatch, a tiny thing eight feet square, leading down into the tween deck space and also to the forepeak where the bulk of the coal for the galley was kept. Forward of the coal store were the chain lockers, two vertical shafts in which the anchor cables were faked down link by link as they came in over the windlass pawls above. In the forepeak were great coils of wire strop, mooring springs and towing hawser, and for some distance aft in the ’tween-deck the space was filled with a pell-mell of bundled sail. The ’tween-deck was really an upper hold eight feet high, extending the length and breadth of the ship as far as the after peak, or lazarette, beneath the poop. This deck was pierced through by tonnage openings of the same size as the hatches above them. At sea both the hatches above and the tonnage openings below were battened down, cutting off the upper and lower holds. There was no artificial light below and because of this there was to be a nasty accident quite soon.

Next to No 1 hatch the great trunk of the foremast rose up through the deck from its roots on the keelson of the ship. By the mast was a teak fife rail with iron belaying pins to which the headsail halliards and the sheets of four square sails above the lower topsail were belayed; the lower topsail and foresail sheets were belayed to cleats on the fore part of the mast itself. Not far distant from the fore mast were the halliard winches for raising the upper topsail yards and topgallant yards when setting sail. The royal halliards rove through blocks and were belayed to the pin rails. It took ten men to raise a royal yard. The square sail halliards were so placed that with the yards raised they became in effect additional backstays.

Abaft the foremast was the donkey boiler room with a hinged funnel on top where Jansson and his even more savage-looking superior tended their charge, which was intended to raise the anchors. On very rare occasions it provided power for sending aloft the heavier sails. Here the Donkeymen kept the tools of their trade, which included a blacksmith’s forge, spares for the winches and, an important item, a blow-lamp with which they were always brewing cocoa, happily independent of the irascible cook. On either side of the donkey house was a capstan to which the sheets of the great foresail were brought through fairleads in the bulwarks. They were also used to send sail aloft by manpower.

Between the donkey house and the raised bridge deck amidships was No 2 hatch with Jansson’s dismantled winch beside it. Here the Belfast stevedores, using shore cranes, were unloading with an almost ritualistic deliberation, like figures in a slow-motion film of a coronation ceremony. To port and starboard were the pin rails for the forebraces which controlled the final angle or trim of the foresail and upper and lower topsail yards after they had been roughly braced round with a Jarvis brace winch. Only the course and topsail yards on each mast were operated by winches. The hand braces for the topgallant and royal yards came down to the deck still farther aft on the midships section, and were belayed to the fife rail at the mainmast.

Next to the mainmast was the Jarvis brace winch for the foremast yards with which four men could brace round the course and upper and lower topsail yards according to the direction of the wind, the wire braces playing out on cone-shaped drums on one side of the winch, whilst the slack was taken up by a similar set on the other side. There were three Jarvis brace winches in Moshulu, which eased what would otherwise have been an almost impossible task in so large a vessel for a crew as small as ours. The remaining yards, the two topgallants and the royals, were braced round with long rope braces. In the same way those operated by the winch had also to be trimmed properly by hand.

The forepart of the raised bridge-deck was painted white and had brass scuttles set in it. These portholes shed some light into the port and starboard fo’c’sles and into the galley where the Cook, that most wretched of men, lived in a stifling atmosphere filled with escaping steam, looking very much like ‘the Spirit of the Industrial Revolution’ in a Nursery History of England. The bridge deck, sixty-five feet long, forty-seven feet on the beam, was connected with the fo’c’sle head and poop decks by flying bridges over the fore and main decks which enabled the Mates to move about more quickly when issuing orders. On the bridge-deck was the charthouse, a massive construction where the charts, sailing directions, log-book, barometer and navigational instruments were housed. A companion-way led below to the Officers’ quarters.

Right amidships were the two massive teak wheels connected with the steering-gear aft by well-greased wire cables running through sheaves in the deck. These cables would sometimes break when a heavy sea was running. In a big gale three men would stand on the raised platforms to assist the helmsman who checked the more violent movements of the wheel with a foot-brake set in the floor. In front of the wheel was the big brass binnacle and behind the helmsman was the ship’s bell on which he echoed the striking of the clock inside the charthouse. On a brass plaque below the bell was engraved: Wm. Hamilton, Shipbuilders, Port Glasgow.